Predictive Modeling of Globule Size Distribution in Double Emulsions Stabilized by Blended Surfactants and Nanoparticles using Hinze-Kolmogorov Theory
DOI:
https://doi.org/10.11113/mjfas.v22n1.4966Keywords:
Emulsion liquid membrane, Hinze-Kolmogorov theory, emulsion stability, globule size prediction, W/O/W emulsionAbstract
Emulsion liquid membrane (ELM) is effective for heavy metal extraction, with efficiency closely linked to stability, which is largely governed by the size of the water-in-oil-in-water (W/O/W) emulsion globules. The applicability of Hinze-Kolmogorov theory for predicting Sauter mean diameters (D32) of W/O/W emulsion embedded with blended surfactant-nanoparticle was scrutinized. A MATLAB code was developed based on this theory and the experimental data on zinc extraction was used for validation. Afterwards, several parameters such as impeller diameter, agitation speed, interfacial tension, and holdup fraction were investigated. The developed model is viable for predicting globule size, with minimal average absolute relative deviation of less than 5%. The new empirical correlation with C1=0.0436 and C2=-3.2561 was obtained. Based on the simulation, it can be deduced that the impeller diameter and agitation speed are inversely proportional to the globule size, and smaller interfacial tensions typically produce smaller globules.
References
Rahman, D. Z., Vijayaraghavan, J., & Thivya, J. (2023). A Comprehensive Review on Zinc(II) Sequestration from Wastewater Using Various Natural/Modified Low-Cost Agro-Waste Sorbents. Biomass Conversion and Biorefinery, 13(7), 5469–5499.
Yang, K. J., Fong, L. L., Kee, C. M., & Saeed, A. A. (2022). Kinetic Study for Adsorption of Heavy Metals on Zeolite. Journal of Harbin Institute of Technology (New Series), 29(1), 70–76.
Hussaini, S., & Tita, A. M. (2023). Zinc and Lead Solvent Extraction and Electrowinning, in The Minerals, Metals and Materials Series. Springer. p. 403-459.
Da̧browski, A., Hubicki, Z., Podkościelny, P., & Robens, E. (2004). Selective Removal of the Heavy Metal Ions from Waters and Industrial Wastewaters by Ion-Exchange Method. Chemosphere, 56(2), 91-106.
Gulnaziya, I., Nicholas, Y. J., Mohammad, A. A., Farihahusnah, H., & Mohamed, K. A. (2020). Removal of Zinc from Wastewater Through the Reduction Potential Determination and Electrodeposition Using Adsorption-Desorption Solutions. Iranian Journal of Chemistry and Chemical Engineering, 39(6), 121-130.
Tan, S., Zhang, T., Cheng, C., Wang, Z., Li, H., & Zhao, Y. (2025). Efficient Removal and Stepwise Recovery of Various Heavy Metals from Water by Using Calcium Carbonate with Different Activity. Separation and Purification Technology, 354(5), 129142.
Suliman, S. S., Othman, N., Noah, N. F. M., & Kahar, I. N. S. (2023). Extraction and Enrichment of Zinc from Chloride Media Using Emulsion Liquid Membrane: Emulsion Stability and Demulsification via Heating-Ultrasonic Method. Journal of Molecular Liquids, 374, 121261.
Kahar, I. N. S., Othman, N., Idrus-Saidi, S. A., Noah, N. F. M., Nozaizeli, N. D., & Suliman, S. S. (2024). Integrated Emulsion Liquid Membrane Process for Enhanced Silver Recovery from Copper-Silver Leached Solution. Chemical Engineering Research and Design, 212, 434-444.
Suliman, S. S., Othman, N., Noah, N. F. M., Johari, K., & Ali, N. A. (2022). Stability of Primary Emulsion Assisted with Nanoparticle in Emulsion Liquid Membrane Process for Zinc Extraction. Materials Today: Proceedings, 65, 3081-3092.
Yan, J., & Pal, R. (2001). Osmotic Swelling Behavior of Globules of W/O/W Emulsion Liquid Membranes. Journal of Membrane Science, 190(1), 79-91.
Mohammed, A. A., Atiya, M. A., & Hussein, M. A. (2020). Removal of Antibiotic Tetracycline Using Nano-Fluid Emulsion Liquid Membrane: Breakage, Extraction and Stripping Studies. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 595(124680.
Sun, Z., Yan, X., Xiao, Y., Hu, L., Eggersdorfer, M., Chen, D., Yang, Z., & Weitz, D. A. (2022). Pickering Emulsions Stabilized by Colloidal Surfactants: Role of Solid Particles. Particuology, 64(153-163.
Esmaeilzadeh, P., Hosseinpour, N., Bahramian, A., Fakhroueian, Z., & Arya, S. (2014). Effect of ZrO2 Nanoparticles on the Interfacial Behavior of Surfactant Solutions at Air–Water and N-Heptane–Water Interfaces. Fluid Phase Equilibria, 361(289-295.
Raji-Asadabadi, M., Abolghasemi, H., Maragheh, M. G., & Davoodi-Nasab, P. (2013). On the Mean Drop Size of Toluene/Water Dispersion in the Presence of Silica Nanoparticles. Chemical Engineering Research and Design, 91(9), 1739-1747.
Fujii, S., Okada, M., & Furuzono, T. (2007). Hydroxyapatite Nanoparticles as Stimulus-Responsive Particulate Emulsifiers and Building Block for Porous Materials. Journal of Colloid and Interface Science, 315(1), 287-296.
Davoodi-Nasab, P., Abolghasemi, H., Safdari, J., & Raji-Asadabadi, M. (2014). Mean Drops Size in The Presence of Cetyl Trimethyl Ammonium Bromide in Horizontal Mixer Settler. Asia-Pacific Journal of Chemical Engineering, 9(1), 93-104.
Othman, N., Kahar, I. N. S., Long, S. S., Noah, N. F. M., Idrus-Saidi, S. A., & Suliman, S. S. (2024). Prediction of Zinc Extraction from Aqueous Solution Using Iron Oxide Nanoparticles Embedded Formulation for Tuning Emulsion Liquid Membrane Stability. Chemical Engineering Research and Design, 204(572-584.
Suliman, S. S., Othman, N., Noah, N. F. M., Jusoh, N., & Sulaiman, R. N. R. (2021). Empirical Correlation of Emulsion Size Prediction for Zinc Extraction Using Flat Blade Impeller System in Emulsion Liquid Membrane Process. Malaysian Journal of Fundamental and Applied Sciences, 17(6), 742-751.
Jusoh, N., Othman, N., Ambi, L. L. A. A., Noah, N. F. M., Rosly, M. B., & Rahman, H. A. (2022). Empirical Correlation of Stable Double Emulsion System of Organic Compound Extraction in Emulsion Liquid Membrane Process. Malaysian Journal of Fundamental and Applied Sciences, 18(197-205.
Zhao, P., Fan, W., Zhang, L., & Nan, G. (2013). Study on Influencing Factors on Particle Size and Stability of Asphalt Emulsion and Their Correlation. Petroleum Processing and Petrochemicals, 44(7), 12-16.
Farsoiya, P. K., Liu, Z., Daiss, A., Fox, R. O., & Deike, L. (2023). Role of Viscosity in Turbulent Drop Break-Up. Journal of Fluid Mechanics, 972, A11.
Khakpay, A., Abolghasemi, H., & Salimi-Khorshidi, A. (2009). The Effects of a Surfactant on Mean Drop Size in a Mixer-Settler Extractor. Chemical Engineering and Processing: Process Intensification, 48(6), 1105-1111.
Lee, J. M., & Soong, Y. (1985). Effects of Surfactants on the Liquid-Liquid Dispersions in Agitated Vessels. Industrial & Engineering Chemistry Process Design and Development, 24(1), 118-121.
El-Hamouz, A., Cooke, M., Kowalski, A., & Sharratt, P. (2009). Dispersion of Silicone Oil in Water Surfactant Solution: Effect of Impeller Speed, Oil Viscosity and Addition Point on Drop Size Distribution. Chemical Engineering and Processing: Process Intensification, 48(2), 633-642.
Desnoyer, C., Masbernat, O., & Gourdon, C. (2003). Experimental Study of Drop Size Distributions at High Phase Ratio in Liquid–Liquid Dispersions. Chemical Engineering Science, 58(7), 1353-1363.
Khakpay, A., Abolghasemi, H., & Montazer-Rahmati, M. M. (2010). The Effect of Sodium Dodecyl Sulfate on Mean Drop Size in a Horizontal Mixer–Settler Extractor. The Canadian Journal of Chemical Engineering, 88(1), 101-108.
Noah, N. F. M., Othman, N., & Binanga, H. (2022). Prediction of Zinc Extraction Using Facilitated Emulsion Liquid Membrane Model. Malaysian Journal of Fundamental and Applied Sciences, 18(2), 206-217.
Pandey, S. (2023). Optimization of PID Controller Parameters for Speed Control of DC Motor Using Firefly and Fminsearch Algorithms. SSRN.
Ohtake, T., Hano, T., Takagi, K., & Nakashio, F. (1987). Effects of Viscosity on Drop Diameter of W/O Emulsion Dispersed in a Stirred Tank. Journal of Chemical Engineering of Japan, 20(5), 443-447.
Kumar, A., Thakur, A., & Panesar, P. S. (2019). A Review on Emulsion Liquid Membrane (ELM) for the Treatment of Various Industrial Effluent Streams. Reviews in Environmental Science and Bio/Technology, 18(1), 153-182.
Hussein, M. A., Mohammed, A. A., & Atiya, M. A. (2019). Application of Emulsion and Pickering Emulsion Liquid Membrane Technique for Wastewater Treatment: An Overview. Environmental Science and Pollution Research, 26(36), 36184-36204.
Cong, Y., Zhang, W., Liu, C., & Huang, F. (2020). Composition and Oil-Water Interfacial Tension Studies in Different Vegetable Oils. Food Biophysics, 15(2), 229-239.
Chakraborty, M., Bhattacharya, C., & Datta, S. (2003). Effect of Drop Size Distribution on Mass Transfer Analysis of the Extraction Of Nickel(II) by Emulsion Liquid Membrane. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 224(1), 65-74.
Schroën, K., de Ruiter, J., & Berton-Carabin, C. (2020). The Importance of Interfacial Tension in Emulsification: Connecting Scaling Relations Used in Large Scale Preparation with Microfluidic Measurement Methods. ChemEngineering, 4(4), 63.
Peng, L., Yang, M., Guo, S. S., Liu, W., & Zhao, X. Z. (2011). The Effect of Interfacial Tension on Droplet Formation in Flow-Focusing Microfluidic Device. Biomedical Microdevices, 13(3), 559-564.
Chow, M. C., & Ho, C. C. (2000). Surface Active Properties of Palm Oil with Respect to the Processing of Palm Oil. Journal of Oil Palm Research, 12(1), 107-116.
Javanshir, S., Abdollahy, M., & Abolghasemi, H. (2012). Drop Size Distribution in a Mixer–Settler Reactor for the Gold Chloride/DBC System. Chemical Engineering Research and Design, 90(10), 1680-1686.
Abbassian, K., & Kargari, A. (2016). Effect of Polymer Addition to Membrane Phase to Improve the Stability of Emulsion Liquid Membrane for Phenol Pertraction. Desalination and Water Treatment, 57(7), 2942-2951.
Goyal, R. K., Jayakumar, N. S., & Hashim, M. A. (2011). A Comparative Study of Experimental Optimization and Response Surface Optimization of Cr Removal by Emulsion Ionic Liquid Membrane. Journal of Hazardous Materials, 195(383-390.
Djenouhat, M., Hamdaoui, O., Chiha, M., & Samar, M. H. (2008). Ultrasonication-Assisted Preparation of Water-in-Oil Emulsions and Application to the Removal of Cationic Dyes from Water by Emulsion Liquid Membrane: Part 2. Permeation and stripping. Separation and Purification Technology, 63(1), 231-238.
Kulkarni, P. S., & Mahajani, V. V. (2002). Application of Liquid Emulsion Membrane (LEM) Process for Enrichment of Molybdenum from Aqueous Solutions. Journal of Membrane Science, 201(1), 123-135.
Jusoh, N., Othman, N., Sulaiman, R. N. R., Noah, N. F. M., & Zaini, M. A. A. (2022). Optimization of Synergistic Green Emulsion Liquid Membrane Stability for Enhancement of Silver Recovery from Aqueous Solution. Korean Journal of Chemical Engineering, 39(2), 423-430.
Wan, Y., & Zhang, X. (2002). Swelling Determination of W/O/W Emulsion Liquid Membranes. Journal of Membrane Science, 196(2), 185-201.
Jusoh, N., & Othman, N. (2016). Stability of Water-in-Oil Emulsion in Liquid Membrane Prospect. Malaysian Journal of Fundamental and Applied Sciences, 12(3), 114-116.
Kahar, I. N. S., Ali, A. S., Othman, N., Noah, N. F. M., & Suliman, S. S. (2023). Copper Extraction Using LIX 84 as a Mobile Carrier in the Emulsion Liquid Membrane Process. Journal of Applied Membrane Science & Technology, 27(3), 69-80.
Kitagawa, T., Nishikawa, Y., Frankenfeld, J., & Li, N. (1977). Wastewater Treatment by Liquid Membrane Process. Environmental Science & Technology, 11(6), 602-605.
Downloads
Published
Issue
Section
License
Copyright (c) 2026 Norasikin Othman, Tan Yi Hao, Norul Fatiha Mohamed Noah, Norela Jusoh, Izzat Naim Shamsul Kahar, Sazmin Sufi Suliman, Shuhada A. Idrus-Saidi, Aishah Rosli
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
